Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
0802801
MOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION. *TT
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
0300604
FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT
1900204
STEERING COLUMN CLICK SOUND. *TT
1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
0802502
AIR BAG LIGHT ON WITH ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) STORED ENERGY FAULT SET. *TT
02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
1801302A
ENGINE PERFORMANCE ENHANCEMENTS / ROUGH IDLE IN DRIVE. *TT
1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
27
THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT
02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
0900502
SUBJECT REGARDING ENGINE OIL IN COOLANT RESERVOIR. *TT
2100102
SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2303202
SUBJECT REGARDING INSTRUMENT PANEL MAT (PENCIL TRAY) ADHESION. *SLC
02010
LEFT FRONT STEERING KNUCKLE/ABS TONE WHEEL INTERFERENCE. *SLC
02006
SUBJECT REGARDING TRANSMISSION CONTROL MODULE (TCM) FLASH PROCEDURE WILL NOT WORK. *SLC
1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
1801302
SUBJECT REGARDING ENGINE PERFORMANCE ENHANCEMENTS. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2200102
CHROME WHEEL CARE. *SLC
01017
RAPID RESPONSE TRANSMITTAL REGARDING A/C SYSTEM OVERCHARGE. *TT
0802301
SUBJECT REGARDING STATIC ON STRONG AM RADIO STATIONS. *TT
0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
993
A CONDITION MAY EXIST REGARDING AN INACCURATE ODOMETER READING. *TT
0801901
SOME VEHICLES EQUIPPED WITH VEHICLE THEFT ALARM WILL NO LONGER DISARM OR ARM THE ALARM FROM THE FRONT PASSENGER DOOR USING THE KEY. *TT
0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
01016
ADVANCE SERVICE INFORMATION REGARDING ALARM REMOTE KEYLESS ENTRY MODULE (ARKEM) SHIPPING MODE ELIMINATION. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.