25H05 S1
Other
Harvest Program 25H05 – Supplement #1 Certain 2011-2021 Model Year Vehicles Software Verification Harvest Program
Vehicle report
2012 FORD FOCUS
Service bulletins
123 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 54601
Service Bulletin/Repair Instructions
Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k
25H05
Other
This is a proactive investigation program by Ford Motor Company to inspect a limited number of affected vehicles that are customer-owned. Ford is voluntarily conducting this program to evaluate the software currently installed on one or more electronic modules in the affected vehicles.
24N07
Other
Certain 2012 – 2018 Model Year Focus Vehicle Line One-Time Canister Purge Valve Replacement
SSM 53040
Service Bulletin/Repair Instructions
While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
SSM 52476
Service Bulletin/Repair Instructions
All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
14M02 S7
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2016 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission Transmission Control Module Extended Warranty Coverage REASON FOR THIS SUPPLEMENT âÃÂâ Due to ongoing limited part availability, program terms have been revised. âÃÂâ Vehicle pickup & delivery has been added. âÃÂâ Labor allowance table has been updated. âÃÂâ Additional repairs updated. âÃÂâ Added Attachment VI Mobile Repair/Vehicle Pickup and Delivery Record. âÃÂâ Added Attachment VII Mobile Repair Assessment.
SSM 51536
Service Bulletin/Repair Instructions
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
14M02 06
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2016 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission; Transmission Control Module Extended Warranty Coverage REASON FOR THIS SUPPLEMENT Non-Ford Part Usage: ⢠Vehicles that are still covered by the 8 years/80,000-mile Emissions warranty coverage MUST be serviced with a NEW Ford Motor Company TCM. ⢠Vehicles outside of or exceeding the 8 years/80,000-mile coverage are authorized to use a used Ford Motor Company TCM, a refurbished original Ford TCM, or an aftermarket TCM that will successfully complete the required Ford software updates.
SSM 50258
Service Bulletin/Repair Instructions
Various 2012-2015 vehicles equipped with a 3G modem may experience a lack of 3G modem performance. This may be due to the 3G cellular service functionality being decommissioned starting August 2021 and through March 2022. As the 3G cellular service is decommissioned, vehicles equipped with the 3G telematics control unit (TCU) will lose MyFord Mobile and MyLincoln Mobile app functionality/connectivity. Repair or Replacement of the TCU should no longer be performed using existing service stock. Replacement of the 3G TCU for this concern will result in programming concerns and repairs should not be performed.
14M02-S5
Service Bulletin/Repair Instructions
Ford is extending the warranty coverage on the DPS6 automatic transmission TCM to 10 years of service or 150,000 miles from the warranty start date of the vehicle, whichever occurs first. This extended warranty coverage will address intermittent symptoms of loss of transmission engagement while driving, no-start, or a lack of power.
20B22-S4
Service Bulletin/Repair Instructions
This customer satisfaction program updates the TCM software in affected vehicles to provide improved detection and over warning of electrical circuit failures in the TCM. As communicated in a previous Customer Satisfaction Program (14M02), electrical circuit failures within the TCM may develop and result in intermittent symptoms of loss of transmission engagement while driving, no-start, or a lack of power. Updating the TCM software will help ensure the vehicle operator is alerted to potential issues with the TCM prior to failure.
SSM 48858
Service Bulletin/Repair Instructions
Some 2012-2020 Ford and Lincoln vehicles equipped with a TCU may exhibit an inoperative remote start with a 'Vehicle Failed To Start' message when using MyFord Mobile/Ford Pass/Lincoln Way mobile applications. The cellular cloud systems will only allow two remote start requests from the MyFord Mobile/Ford Pass/Lincoln Way apps without a vehicle drive event occurring. If a third remote start request is received, a Vehicle Failed To Start message will be displayed quickly in the mobile app. Once the vehicle is driven, the remote start counter is reset and will allow remote start commands to be sent from the mobile app. If the remote start system is not functioning using the key fob, refer to Workshop Manual (WSM) Section 303-06 for further diagnosis.
TSB 20-2140
Service Bulletin/Repair Instructions
Some 2012-2016 Focus Electric vehicles built on 15-Sep-2011 and through 9-Dec-2015 may exhibit a Stop Safely Now message displayed in the instrument panel cluster (IPC) message center. This may be due to either an internal coolant leak on the upper or lower high voltage battery or corrosion on the lower high voltage battery connector caused by water ingress. If this occurs, the vehicle may not restart once it has been shut off. To resolve the condition, follow the Service Procedure to replace the upper and lower high voltage battery or apply corrosion protection.
TSB 20-2004
Service Bulletin/Repair Instructions
Some 2012-2018 Focus Electric vehicles may exhibit a Stop Safely Now message displayed in the instrument panel cluster (IPC) message center. This may be due to either an internal coolant leak on the upper or lower high voltage battery or corrosion on the lower high voltage battery connector caused by water ingress. If this occurs, the vehicle may not restart once it has been shut off. To resolve the condition, follow the Service Procedure to replace the upper and lower high voltage battery or apply corrosive protection.
14M01-S7
Service Bulletin/Repair Instructions
Certain 2011 through 2014 Model Year Fiesta and Focus Vehicles Equipped with a DPS6 Automatic Transmission - Transmission Clutch Shudder / Transmission Input Shaft Seal Warranty Extension
14M02-S4
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2016 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission - Transmission Control Module Extended Warranty Coverage
19N07-S1
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2014 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission - Transmission Control Module Service Warranty Coverage
15B22-S3
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2014 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission - Transmission Control Module Reprogramming for Overt TCM Failure Warning
19N07
Service Bulletin/Repair Instructions
Certain 2011 through 2015 Model Year Fiesta and 2012 through 2014 Model Year Focus Vehicles Equipped with a DPS6 Automatic Transmission - Transmission Control Module Extended Warranty Coverage
SSM 48130
Service Bulletin/Repair Instructions
Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found, inspect the area of the glass that is covered by the cowl and/or molding. The portion of glass that is covered by the cowl or molding will not be affected by the acid. Hydrofluoric acid damage is not a defect in material or workmanship and is not a warrantable condition.
SSM 48123
Service Bulletin/Repair Instructions
For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable clamp and clean the cable end as necessary to preserve wire length. Some rework may be necessary for some vehicle environments. Bend the new positive battery cable clamp as needed and crimp it to the existing battery cable. Make sure to use heat shrink tubing over the battery cable to battery cable clamp connection. Obtain the heat shrink tube locally.
DPS6 Dealer Com.
Service Bulletin/Repair Instructions
Short-Term DPS6 Dealer Customer Handling Direction
SSM 47976
Service Bulletin/Repair Instructions
On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.
SSM 47749
Service Bulletin/Repair Instructions
Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
TSB 18-2373
Service Bulletin/Repair Instructions
Some 2012-2018 Focus Electric, 2013-2017 C-Max Energi, and 2013-2019 Fusion Energi plug-in hybrid electric vehicles (PHEV) may exhibit the high voltage (HV) battery failing to charge while connected to the second Generation 120-volt electric vehicle service equipment (EVSE) charge cord. Follow the Service Procedure steps to correct the condition.
TSB 18-2352
Service Bulletin/Repair Instructions
Some 2012-2018 Focus BEV vehicles may exhibit a lack of A/C. This may be due to a high-voltage battery coolant cooler (chiller) leak that may have been caused by prior transmission service. Follow the Service Procedure steps to correct the condition.
SSM 47563
Service Bulletin/Repair Instructions
Some 2011-2014 Fiesta and 2012-2014 Focus vehicles equipped with a DPS6 transmission may experience a fluid leak between the engine and transmission. Be aware that the engine oil and DPS6 transmission fluid are similar in color and texture. A transmission fluid leak at the input shaft seal can cause a buildup of fluid in the bell housing; creating the appearance of a rear main seal leak. The rear main seal should only be replaced after a rear main seal failure is confirmed through appropriate diagnostics outlined in the updated online Workshop Manual (WSM) Section 303-00 / Diagnosis and Testing with the use of Fluorescent dye (164-TP33200601).
SSM 47528
Service Bulletin/Repair Instructions
Some 2012-2018 Focus BEV vehicles may exhibit DTC U0130 in the battery electric control module (BECM) after replacement of the high voltage (HV) battery pack. In order to correct the condition, perform a programmable module installation (PMI) using the appropriate Ford scan tool. This action will initiate a coordinated flash of powertrain control module (PCM) and transmission control module (TCM) for HV battery compatibility. The use of a previous session may also cause DTC U1030 to be present in the BECM. For additional information refer to 2015 or newer Workshop Manual (WSM), Section 414-03A
SSM 47201
Service Bulletin/Repair Instructions
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems. If you suspect a system has been modified, the following resources can be used to verify original equipment: Monroney Label (Window Sticker), Professional Technician Society (PTS) OASIS tab select SYNC or HVBOM. For Genuine Ford accessories use: PTS Workshop Tab select Dealer Installed Accessory or Accessory Installation.
SSM 47198
Service Bulletin/Repair Instructions
Some 2013-2017 Fusion Energi, 2012-2017 Focus Electric and 2013-2017 C-MAX Energi vehicles equipped with a TCU built on or before 11-Oct-2017 may exhibit a discharged battery, inoperative remote features via MyFord Mobile app, incomplete user authorization and/or accessory protocol interface module (APIM) DTC U0198 with no modem electronic serial number (ESN) displayed. To correct this condition, perform any open TCU field service actions (FSAs). If U0198 DTC still remains, remove the TCU fuse for 5 minutes then reinstall. Reprogram the TCU using IDS or Ford J2534 Diagnostic Software (FJDS) release 108.05 or higher. An internet connection is required. Calibration files may also be obtained at www.motorcraftservice.com. For claiming, use causal part 14G229 and applicable labor operations in section 10 of the SLTS manual
SSM 47161
Service Bulletin/Repair Instructions
Some 2012-2017 Focus BEV, 2013-2016 Fusion Energi And 2013-2017 CMAX Energi vehicles equipped with a Telematics Control Unit (TCU) may exhibit inoperative remote features via My Ford Mobile app, discharged battery, incomplete user authorization and/or diagnostic trouble code (DTC) U0198 with no modem electronic serial number (ESN) displayed. To correct this condition, perform any open TCU field service actions (FSAs). If DTC U0198 remains, remove the TCU fuse for 5 minutes then reinstall prior to programming. Perform IDS Network Test and reprogram the TCU using Integrated Diagnostic System (IDS) release 108.05 or higher. An internet connection is required. Calibration files may also be obtained at www.motorcraftservice.com. For claiming, use causal part 14G229 and applicable labor operations in section 10 of the SLTS manual.
SSM 47130
Service Bulletin/Repair Instructions
Some 2012-2018 Focus Electric, 2013-2017 C-Max Energi, and 2013-2018 Fusion Energi plug-in hybrid electric vehicles (PHEV) may exhibit the high voltage (HV) battery failing to charge while connected to the Delphi 120 volt electric vehicle service equipment (EVSE) charge cord. To identify a Delphi EVSE the coupler on the EVSE that connects to the vehicle charge port is solid black. For information on the Delphi EVSE indicator status used for diagnostics, reference High Voltage Battery > Charging the High Voltage Battery in the Owners Guide for a 2018 Fusion Energi. Reference the Convenience Cord Light Emitting Diode (LED) Indicators chart. The Workshop Manual (WSM) is scheduled to be revised at a later date.
TSB18-2062
Service Bulletin/Repair Instructions
Some 2012-2014 Focus vehicles equipped with a 2.0L gasoline direct injection (GDI) engine may exhibit concerns of engine runs rough, crank no-start, loss of power, loss of engine RPM, and/or illuminated MIL with diagnostic trouble codes (DTCs) P0122, P0222, P0320, P0322, P0327, P0332, P0344, P0369, P06A7, P060D, P061C, P1336, P1674, P2111, P2112, P2127 and/or P2135. Follow the Service Procedure steps to correct the condition.
SSM 47080
Service Bulletin/Repair Instructions
2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
SSM 47009
Service Bulletin/Repair Instructions
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.
SSM 46900
Service Bulletin/Repair Instructions
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the on-screen instructions to complete the procedure. This procedure will transfer the existing Key ID information between the modules without the need of having 2 programmed PATS keys present. There is no need to program keys when the PCM is going to be replaced. Additional information can be found in the Workshop Manual (WSM), Section 419-01. Missing or lost keys are not warrantable.
SSM 46547
Service Bulletin/Repair Instructions
Some 2012-13 Focus and 2013 Escape/C-MAX vehicles may have the wrong part in the box for the BCM (base 14A068). The suspect service part number is GV6Z-14A068-G. The wrong part will have an engineering number of GV6T-14A073-GD and it will not work. The correct part will have engineering part number of GV6T-14A073-with a suffix of XA, XB, XC, or XF. Dealers should utilize the normal return process of a miss packaged part. Continue to monitor OASIS. When this concern is resolved, an update will be provided.
SSM 46534
Service Bulletin/Repair Instructions
Some 2013-2017 Fusion Hybrid Energi built on or before 24-Mar-2017, 2012-2016 Focus Electric and 2013-2016 C-MAX Energi and equipped with a TCU may exhibit inoperative remote features via MyFord Mobile app, discharged battery, incomplete user authorization and/or accessory protocol interface module (APIM) DTC U0198 with no modem electronic serial number (ESN) displayed. To correct, perform any open TCU field service actions (FSAs). If U0198 DTC remains, remove the TCU fuse for 5 minutes then reinstall prior to programming. Reprogram the TCU using Integrated Diagnostic System (IDS) release 104.05 or higher. An internet connection is required. Calibration files may also be obtained at www.motorcraftservice.com. For claiming, use causal part 14G229 and applicable labor operations in section 10 of the SLTS manual.
14M02-S3
Service Bulletin/Repair Instructions
CERTAIN 2011 THROUGH 2015 MODEL YEAR FIESTA AND 2012 THROUGH 2016 MODEL YEAR FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION - TRANSMISSION CONTROL MODULE EXTENDED WARRANTY COVERAGE
SSM 46358
Service Bulletin/Repair Instructions
2011-2017 FIESTA AND 2012-2017 FOCUS SERVICE PIGTAIL FOR TRANSMISSION CONTROL MODULE CONNECTOR C1750A IS AVAILABLE. IF REPAIRS ARE NEEDED USE PART NUMBER FU2Z-14S411-VA. REPLACEMENT OF WIRING HARNESS 12A581 IS NO LONGER REQUIRED WHEN THIS CONNECTOR NEEDS SERVICING.
SSM 46332
Service Bulletin/Repair Instructions
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR LINCOLN VEHICLE. ONLY APPROVED GENUINE FORD ACCESSORIES OR ORIGINALLY INSTALLED SYSTEMS ARE SUPPORTED AND CERTIFIED TO FUNCTION CORRECTLY WITH OTHER VEHICLE SYSTEMS. IF YOU SUSPECT A SYSTEM HAS BEEN MODIFIED, THE FOLLOWING RESOURCES CAN BE USED TO VERIFY ORIGINAL EQUIPMENT: MONRONEY LABEL (WINDOW STICKER), PROFESSIONAL TECHNICIAN SOCIETY (PTS) OASIS TAB SELECT SYNC OR HVBOM. FOR GENUINE FORD ACCESSORIES USE: PTS WORKSHOP TAB SELECT DEALER INSTALLED ACCESSORY OR ACCESSORY INSTALLATION.
SSM 46303
Service Bulletin/Repair Instructions
THE 2012-2017 FOCUS WORKSHOP MANUAL (WSM) PROCEDURE FOR OIL PAN AND REAR MAIN OIL SEAL INSTALLATION HAS BEEN REVISED. REFER TO WSM, SECTION 303-01 REMOVAL AND INSTALLATION. THE SEALANT APPLICATION LOCATION HAS BEEN REVISED. SPECIAL ATTENTION SHOULD BE USED AT T-JOINT LOCATIONS FOR CLEANLINESS AND SEALANT APPLICATION.
SSM 46298
Service Bulletin/Repair Instructions
THE EV RANGE AFTER FULLY CHARGING A 2012-2016 FOCUS ELECTRIC, 2013-2016 C-MAX/FUSION ENERGI MAY VARY AFTER EACH CHARGING EVENT. THE WINDOW STICKER INDICATES 0-19 MILE RANGE FOR 2013-2016 CMAX/FUSION ENERGI. VARIATION OF EV RANGE MAY NOT INDICATE A BATTERY OR CHARGING CONCERN. EV RANGE IS SIMILAR TO THE DTE DISPLAY ON GASOLINE VEHICLES, EV RANGE WILL VARY WITH DRIVING/OPERATING CONDITIONS. CONDITIONS INCLUDE: EXTREME OUTSIDE TEMPERATURES, TERRAIN, DRIVING STYLE, CITY OR HIGHWAY DRIVING, TIRE PRESSURE, AND USE OF ACCESSORIES. IF THE CUSTOMER REPLACES THE LOW ROLL RESISTANCE TIRES WITH A MORE AGGRESSIVE TREAD THE RANGE WILL SUFFER. USING THE CABIN HEATER AND A/C, WHICH ARE ELECTRIC, WILL ALSO DECREASE EV RANGE. TO TEMPORARILY REMOVE THE IMPACT OF DRIVING/CLIMATE HISTORY, RESET THE LIFETIME SUMMARY OR DRIVING HISTORY BY USING THE SETTINGS MENU ON THE LEFT SIDE OF THE INSTRUMENT CLUSTER, UNDER DISPLAY
SSM 46295
Service Bulletin/Repair Instructions
TO HELP DIFFERENTIATE ENGINE OIL LEAKS FROM OTHER POSSIBLE SOURCES, A NEW WHITE-COLORED FLUORESCENT ENGINE OIL DYE IS AVAILABLE. WORKSHOP MANUAL (WSM), SECTION 303-00 HAS BEEN REVISED TO REFERENCE THE NEW WHITE-COLORED DYE. THE NEW WHITE FLUORESCENT DYE PROVIDES A DISTINCT WHITE GLOW TO IDENTIFY ENGINE OIL LEAKS. THE NEW WHITE FLUORESCENT DYE REQUIRES A PURE UV DIAGNOSTIC INSPECTION LAMP. THE WHITE-COLORED FLUORESCENT DYE AND PURE UV LAMP ARE NOW IN THE ROTUNDA CATALOG. DYE AND LAMP PART NUMBERS. GASOLINE ONLY DYE: 1 OUNCE BOTTLE 164-TP-33200601. DIESEL ONLY DYE: 8 OUNCE BOTTLE: 164-TP-3320-0008. PURE UV DIAGNOSTIC INSPECTION LAMP 164-TP8695 OR 164-R3748.
SSM 46210
Service Bulletin/Repair Instructions
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES.
SSM 46132
Service Bulletin/Repair Instructions
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. IF THE PARK BRAKE WAS APPLIED WHEN THE VHR WAS GATHERING DATA FROM THE MAJOR VEHICLE SYSTEMS, THE BRAKES AND SUSPENSION MESSAGE WILL BE REPORTED AS THE VHR LOOKS FOR ANY WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER. RERUN THE VHR WITH THE ENGINE ON AND VEHICLE IN PARK, AND ENSURE THE PARK BRAKE IS DISENGAGED. IF THE SYNC VHR IS STILL REPORTING A CONCERN TO THE CUSTOMERS SYNC OWNERS ACCOUNT, REFER TO THE APPROPRIATE WORKSHOP MANUAL SECTION FOR DIAGNOSIS BY DTC OR SYMPTOM. STARTING IN 2015 NOT ALL SYNC EQUIPPED VEHICLES SUPPORT VHR, REFER TO THE OWNERS MANUAL FOR VHR OPERATION.
SSM 46102
Service Bulletin/Repair Instructions
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
TSB 16-0129
Service Bulletin/Repair Instructions
Some 2011-2016 Fiesta and 2012-2016 Focus vehicles equipped with a DPS6 transmission may exhibit intermittent concerns of loss of transmission engagement while driving, intermittent no start or a loss of power. These symptoms are usually accompanied by an illuminated Check Engine lamp. Additional symptoms may include messages in the message center indicating hill start assist is not available, that parking aid malfunction/service is required or the transmission PRNDL/S gear selector on the instrument cluster may flash. Diagnostic trouble codes (DTCs) U0100, U0101, U1013 and/or P0606 will be present or stored in the powertrain control module (PCM) memory. Follow the Service Procedure steps to correct the condition.
SSM 46085
Service Bulletin/Repair Instructions
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
14M01-S6
Service Bulletin/Repair Instructions
CERTAIN 2011 THROUGH 2014 MODEL YEAR FIESTA AND FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION - TRANSMISSION CLUTCH SHUDDER / TRANSMISSION INPUT SHAFT SEAL WARRANTY EXTENSION.
15B22-S2
Service Bulletin/Repair Instructions
CERTAIN 2011 THROUGH 2015 MODEL YEAR FIESTA AND 2012 THROUGH 2014 MODEL YEAR FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION - TRANSMISSION CONTROL MODULE REPROGRAMMING FOR OVERT TCM FAILURE WARNING.
TSB16-0109
Service Bulletin/Repair Instructions
SOME 2011-2015 FIESTA VEHICLES BUILT ON OR BEFORE 10/15/2014 AND 2012-2016 FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION MAY EXHIBIT EXCESSIVE TRANSMISSION CLUTCH SHUDDER ON LIGHT ACCELERATION. SOME VEHICLES MAY OR MAY NOT EXHIBIT TRANSMISSION FLUID LEAKING FROM THE CLUTCH HOUSING. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.
SSM 45941
Service Bulletin/Repair Instructions
2011-2016 FIESTA AND 2012-2016 FOCUS WITH DPS6 TRANSMISSION HAVE A NEW CLUTCH AVAILABLE. THIS CHANGE AFFECTS TCM/PCM CALIBRATIONS. 2011-2013 FIESTA CALIBRATIONS HAVE NOT YET BEEN RELEASED, CONTINUE TO SERVICE WITH BV6Z-7B546-F CLUTCH, PERFORM ANY REPROGRAMMING WITH IDS RELEASE 101.01 ONLY. 2014-2016 FIESTA VEHICLES CONTINUE TO USE FA6Z-7B546-A CLUTCH AND ARE NOT AFFECTED BY CALIBRATION. 2012-2016 FOCUS CAN USE CLUTCH F1FZ-7B546-B FOLLOWING TSB 15-0120 AND FSA 14M01 AND CALIBRATIONS RELEASED WITH IDS 101.02. WORKSHOP MANUALS HAVE BEEN UPDATED TO INCLUDE A REPAIR VALIDATION CODE (RVC) IN DIAGNOSIS BY SYMPTOM, PINPOINT TEST A (FOCUS, 2014-15 FIESTA), PINPOINT TEST N (2011-2013 FIESTA). RVC CODE IS NOT REQUIRED ON WARRANTY CLAIMS AT THIS TIME. ALL PUBLICATIONS WILL UPDATE SOON, WHEN 2011-2013 FIESTA CALIBRATION IS RELEASED.
SSM 45898
Service Bulletin/Repair Instructions
2012-2016 FOCUS SEDAN LUGGAGE COMPARTMENT LID WON'T STAY UP
14M02-S2
Service Bulletin/Repair Instructions
CERTAIN 2011 THROUGH 2015 MODEL YEAR FIESTA AND 2012 THROUGH 2015 MODEL YEAR FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION - TRANSMISSION CONTROL MODULE EXTENDED WARRANTY COVERAGE
15B22-S1
Service Bulletin/Repair Instructions
CERTAIN 2011 THROUGH 2015 MODEL YEAR FIESTA AND 2012 THROUGH 2014 MODEL YEAR FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION - TRANSMISSION CONTROL MODULE REPROGRAMMING FOR OVERT TCM FAILURE WARNING
SSM-45821
Service Bulletin/Repair Instructions
SIRI EYES FREE FUNCTIONAL ISSUES USING BLUETOOTH AND APPLE IOS 9.2 AND 9.2.1
SSM-45815
Service Bulletin/Repair Instructions
AIR CONDITIONING (A/C) INOPERATIVE - DIAGNOSTIC TROUBLE CODE (DTC) P0645
16-0076
Service Bulletin/Repair Instructions
Some 2012-2013 Focus vehicles built on or before 10/22/2012 and 2013 Escape vehicles built on or before 12/3/2012 may exhibit a crunching or creaking type noise from the front suspension on low speed turns and over bumps.
TSB160076
Service Bulletin/Repair Instructions
Crunching or creaking type noise from front of vehicle - low speed turns and bumps
16-0062
Service Bulletin/Repair Instructions
Some 2012-2015 Focus vehicles may exhibit inaccurate fuel gauge indication and/or inaccurate distance to empty. The vehicle may also exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0420, P1450, P0443, P0452, P0456, P0460 and/or P2196.
16B02M
Service Bulletin/Repair Instructions
49 CFR Part 579.5 Monthly Communications - March 2016
16-0044
Service Bulletin/Repair Instructions
DPS6 - NO START AND/OR TRANSMISSION ENGAGEMENT OR LOSS OF POWER WITH DTCS U0100, U0101, U1013, U3003 AND/OR P0606 ISSUE Some 2011-2016 Fiesta and 2012-2016 Focus vehicles equipped with a DPS6 transmission may exhibit intermittent concerns of loss of transmission engagement while driving, intermittent no start or a loss of power. These symptoms are usually accompanied by an illuminated Check Engine lamp. Additional symptoms may include messages in the message center indicating hill start assist is not available, that parking aid malfunction/service is required or the transmission PRNDL/S gear selector on the instrument cluster may flash. Diagnostic trouble codes (DTCs) U0100, U0101, U1013, U3003 and/or P0606 will be present or stored in the powertrain control module (PCM) memory.
TSB160044
Service Bulletin/Repair Instructions
DPS6 - no satart and/or transmission engagement or loss of power with DTCS u0100, U00101, U1013, U3003 AND/OR P0606
14M01
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
14M01S5
Service Bulletin/Repair Instructions
Customer satisfaction Program 14M01 - Supplement #5 Certain 2011 thr ough 2014 Model Year Fies ta and Focus vehicles equipped with a DKPS6 Automatic Transmission Transmission Clautch Shudder/Transmission Input Shaft Seal warranty Extension
TSB-14-0131
Service Bulletin/Repair Instructions
FORD: ON SOME VEHICLES, WITH LIGHT ACCELERATION, TRANSMISSION CLUTCH WOULD SHUDDER, EXCESSIVELY, AND POSSIBLY WOULD LEAK TRANSMISSION FLUID FROM CLUTCH HOUSING. MODEL 2011-14 FIESTA, FOCUS. *PE UPDATED 9/25/2015 *CN
TSB-15-0134
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
CSP-15B-22
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SB-14M02-SUP2
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-15-0120
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB-15-0121
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
TSB15-0120
Service Bulletin/Repair Instructions
FORD: 2012-2015 FOCUS AND 2011-2015 FIESTA MAY EXHIBIT TRANSMISSION FLUID LEAKAGE AND EXCESSIVE TRANSMISSION CLUTCH SHUDDER ON LIGHT ACCELERATION ON VEHICLES THAT HAVE A DPS6 AUTOMATIC TRANSMISSION *CN
TSB15-0121
Service Bulletin/Repair Instructions
FORD: 2011-2015 FIESTA AND 2012-2015 FOCUS MAY SHOW CONCERNS OF LOSS OF TRANSMISSION ENGAGEMENT WHILE DRIVING OR LOSS OF POWER *CN
SB-15B22
Service Bulletin/Repair Instructions
ON CERTAIN VEHICLES, TRANSMISSION CONTROL MODULE (TCM) HAD DEVELOPED ELECTRICAL CIRCUIT FAILURES, RESULTING IN AN INTERMITTENT TRANSMISSION ENGAGEMENT LOSS WHILE DRIVING OR A LACK OF POWER OR NO START AND SOFTWARE NEEDS TO BE REPLACED *CN
44863
Service Bulletin/Repair Instructions
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR SUNROOF ARE OPEN. *TA
ASI-45156
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
ASI-45166
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
15-0043
Service Bulletin/Repair Instructions
FORD 2011-2014 MODEL YEAR FIESTA AND FOCUS VEHICLES EQUIPPED WITH A DPS6 AUTOMATIC TRANSMISSION WILL EXPERIENCE, ON LIGHT ACCELERATION, CLUTCH SHUDDERING. *LJ
15-0036
Service Bulletin/Repair Instructions
FORD 2012-2014 FOCUS: INFORMATION REGARDING CERTAIN VEHICLES EQUIPPED WITH 2.0L GAS DIRECT INJECTION ENGINE MAY CAUSE A CONCERN OF A MIL ENGINE RUNNING ROUGH OR LOSS OF POWER. *LJ
15-0034
Service Bulletin/Repair Instructions
FORD 2012-2014 FOCUS: CERTAIN VEHICLES MAY HAVE INCORRECT FUEL GAUGE INDICATION LAMP WITH DIAGNOSTIC CODES P0420, P1450, P0452,P0456, P0460 OR P2196. *LJ
TSB160062
Service Bulletin/Repair Instructions
Inaccurate fuel gauge or distance to empty indication - built on or before 01/21/2015
44852
Service Bulletin/Repair Instructions
FORD: 2011-2015 FORD FIESTA AND 2012-2014 FORD FOCUS VEHICLES EQUIPPED WITH A DPS6 TRANSMISSION WHEN USING SOLVENTS TO CLEAN THE DPS6 TRANSMISSION BELL HOUSING AND CLUTCH, SHOULD AVOID INPUT SHAFT SEAL EXPOSURE TO SOLVENT. *TA
44855
Service Bulletin/Repair Instructions
FORD: SOME 2013-2015 FORD C-MAX, 2013-2015 FORD ESCAPE, AND 2012-2014 FORD FOCUS EQUIPPED WITH MY FORD TOUCH MAY BE EXPERIENCING COMPACT DISCS GETTING STUCK WHILE ATTEMPTING TO EJECT OUT THE SYSTEM. *TA
14-0215
Service Bulletin/Repair Instructions
FORD FOCUS 2012-2014: BULLETIN INFORMATION INVOLVING CERTAIN VEHICLES EQUIPPED WITH A 2.0L GAS DIRECT INJECTION ENGINE MAY CAUSE A CONCERN OF A MALFUNCTION INDICATOR LAMP ILLUMINATED , ENGINE MAY NOT START OR MAY RUN ROUGH, LOSS OF POWER , OR LOSS OF ENGINE. *LJ
TSB 14-0215
Service Bulletin/Repair Instructions
FORD FOCUS: 2012-2014 FORD FOCUS VEHICLES WITH GAS DIRECT INJECTION ENGINES MAY MALFUNCTION INDICATOR LAMP INDICATOR OR CHECK ENGINE LIGHT. *TA
ASI-44707
Service Bulletin/Repair Instructions
FORD: AFTER POWERTRAIN CONTROL MODULE REPROGRAMMING, THE MALFUNCTION INDICATOR LAMP (MIL) IS ON WITH SEVERAL DIAGNOSTIC TROUBLE CODES (DTC) P06B8, P068A, P2610, IF KEY NOT LEFT FOR 30 SECONDS IN OFF POSITION FOLLOWING PROGRAMMING ON SOME MODEL 2009-15 VEHICLES. *PE
ASI-44736
Service Bulletin/Repair Instructions
FORD: DIAGNOSTIC TROUBLE CODE (DTC) P0217 WILL APPEAR ON VEHICLES WITH GAS DIRECT INJECTION AND A PINPOINT TEST FOR DTC P0217 HAS BEEN UPDATED IN WORKSHOP MANUAL (WSM). MODEL 2012-14 FOCUS. *PE
ASI-44686
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES ARE EXPERIENCING, WITH OR WITHOUT POWERTRAIN DIAGOSTIC TROUBLE CODES (DTC) P0805, P06B8, P0809, P0850, P087A, P087E, P0884, P283A, P2831, P2836, P2837, P2835, AN INTERMITTENT OR DELAYED ENGAGEMENT, AUTOMATIC TRANSMISSION SHIFTING FROM PARK, DRIVE OR REVERSE, NOISE DURING START, INTERMITTENT START, NO CRANK, NO START OR HARD START. MODEL 2012-13 FOCUS. *PE
ASI-44649
Service Bulletin/Repair Instructions
FORD: A JOB AID WAS DEVELOPED AND NOW AVAILABLE FOR THE PTU INTERNAL OR EXTERNAL FLUID LEAKAGE FOR ALL WHEEL DRIVE VEHICLES. *PE
TSB-14-0112
Service Bulletin/Repair Instructions
FORD: AN EARLY SHUT OFF REGARDING A SLOW FILLING OF FUEL OR FILLER FUEL NOZZLE. MODEL 2012-2014 FOCUS. *PE
TSB-14-0078
Service Bulletin/Repair Instructions
FORD: THE FRONT DOOR (LEFT OR RIGHT) FAILS TO OPERATE DUE TO AN INTERMITTENT IA SMART UNLOCK FUNCTION. MODEL 2012-2014 FOCUS, C-MAX, ESCAPE. *PE
TSB-14-0047
Service Bulletin/Repair Instructions
FORD: WHEN TAKING OFF FROM A STOP, USING LIGHT ACCELERATION, THE AUTOMATIC TRANSMISSION WOULD EXHIBIT AN INTERMITTENT TRANSMISSION SHUDDER AND MAY OR MAY NOT BE LEAKING TRANSMISSION FLUID FROM CLUTCH HOUSING. MODEL 2011-2014 FIESTA, FOCUS. *PE
ASI-44452
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE (DTC) B1D06:15 AFTER THE REPLACEMENT OF THE BODY CONTROL MODULE (BCM) AND SHOULD BE IGNORED AND NO REPAIRS OR DIAGNOSTICS PERFORM. MODEL 2012-2014 FOCUS, C-MAX, ESCAPE. *PE
ASI-44460
Service Bulletin/Repair Instructions
FORD: THERE ARE MULTIPLE COMMUNICATION MODULE DIAGNOSTIC TROUBLE CODES (DTC) DUE TO HS-CAN CIRCUIT LOCATED ON UNDERSIDE OF FRONT PASSENGER SEAT SHORTING TO GROUND. MODEL 2012-2014 FOCUS. *PE
ASI-44389
Service Bulletin/Repair Instructions
FORD: DIAGNOSTIC TROUBLE CODE (DTC) 01594 IS SET IN BODY CONTROL MODULE (BCM) AND NO OTHER CODES, AFTER REMOTE STARTING AND WITH A START STALL SYMPTOM, WITHIN 20 SECONDS. MODEL 2012-2014 FOCUS, 2013-2014 ESCAPE, C-MAX. *PE
ASI-44363
Service Bulletin/Repair Instructions
FORD: WITHIN 20 SECONDS AFTER REMOTE STARTING VEHICLE, THERE IS A START STALL ISSUE AND DIAGNOSTIC TROUBLE CODE (DTC) P1594 IS SET IN BODY CONTROL MODULE (BCM). MODEL 2012-2014 FOCUS, 2013-2014 ESCAPE, C-MAX. *PE
TSB-13-12-4
Service Bulletin/Repair Instructions
FORD: AN INACCURATE DISTANCE TO EMPTY OR INACCURATE FUEL GAUGE INDICATION, ON SOME VEHICLES, AND ALSO THERE ARE MULTIPLE DIAGNOSTIC TROUBLE CODES (DTC) WITH ILLUMINATION OF CHECK ENGINE LIGHT. MODEL 2012-2014 FOCUS. *PE
ASI-32314
Service Bulletin/Repair Instructions
FORD: THE CRUISE CONTROL, ON SOME VEHICLES, MAY BE INOPERATIVE DUE TO STEERING WHEEL WIRING HARNESS WITH DIAGNOSTIC TROUBLE CODE (DTC) B112B.07. MODELS 2012-2013 FOCUS, ESCAPE. *PE
ASI-32331
Service Bulletin/Repair Instructions
FORD: THERE ARE SOME CONCERNS, ON SOME VEHICLES, WHERE NO CRANK, NO START, HARD START, INTERMITTENT START, NOISE DURING START AND/OR VARIOUS OTHER TRANSMISSION ISSUES IN DRIVE OR REVERSE, NO ENGAGEMENT WHEN SHIFTING FROM PARK, DELAYED OR INTERMITTENT ENGAGEMENT. MODELS 2012-2013 FOCUS. *PE
ASI-44283
Service Bulletin/Repair Instructions
FORD: DURING COLD AMBIENT TEMPERATURES, AND AT LIGHT ACCELERATION OR COASTING, A GRINDING, SCRAPING NOISE IS HEARD, BETWEEN 20-50 MPH. MODEL 2012-2013 FIESTA, FOCUS. *PE
ASI-44209
Service Bulletin/Repair Instructions
FORD: A MESSAGE IS DISPLAYED REGARDING THE TRANSMISSION OVER HEATING, DUE TO DIAGNOSTIC TROUBLE CODES (DTC) AND MESSAGE CAN BE DISPLAY WITHOUT OVERHEATING OF TRANSMISSION. MODEL 2011-2014 FIESTA, FOCUS.
ASI-44241
Service Bulletin/Repair Instructions
FORD: WHEN OTHER DIAGNOSTIC TROUBLE CODES (DTC) ARE SET, VEHICLES WILL CONCURRENTLY SET A P060D (INTERNAL CONTROL MODULE ACCELERATOR PEDAL POSITION PERFORMANCE) MALFUNCTION INDICATOR LIGHT (MIL). MODEL 2012-2014 FOCUS. *PE
TSB-13-9-19
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES MAY EXPERIENCE ILLUMINATION OF ABS WARNING LAMP, MESSAGE DISPLAY OF STOP SAFELY NOW, RED TRIANGLE WARNING LAMP OR ILLUMINATION OF WRENCH LAMP WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) AND LOW STATE OF CHARGE OF 12 VOLT BATTERY WHEN NOT CONNECTED. MODEL 2012-2014 FOCUS. *PE
ASI-44184
Service Bulletin/Repair Instructions
FORD: TRANSMISSION FLUID LEAKED ON CLUTCH ASSEMBLY AND BY USING METAL PARTS CLEANER, CONTAINING 60% ACETONE OR 60% HEPTANE, EFFECTIVELY, WILL CLEAN FLUID. MODEL 2011-2014 FIESTA, FOCUS. *PE
TSB-13-6-27
Service Bulletin/Repair Instructions
FORD: ON SOME VEHICLES, WHEN VEHICLE HAS BEEN STARTED, THE INSTRUMENT CLUSTER FAILS TO OPERATE AND POSSIBLY NEED TO BE REPROGRAM TO LATEST CALIBRATION. MODEL 2011-2012 FOCUS. *PE
TSB-13-6-17
Service Bulletin/Repair Instructions
FORD:LINCOLN: ON SOME VEHICLES, THERE ARE VARIOUS RELATED CONCERNS ABOUT THE SYNC FEATURES, SUCH AS SYNC FEATURES INOPERATIVE, LACK OF OR SLOW RESPONSE TO PHONE AND VOICE BUTTON OPERATION. MODELS 2012-2013 FOCUS, E-SERIES, EDGE, EXPEDITION, FUSION, EXPLORER, F-150, F-250, NAVIGATOR, 2013-2014 FLEX, 2012-2014 FIESTA, MUSTANG, 2013 ESCAPE, C-MAX, TAURUS, 2012 MKZ. *PE
TSB-13-5-11
Service Bulletin/Repair Instructions
FORD: WHEN DRIVING OVER BUMPS OR MAKING LOW SPEED TURNS, SOME VEHICLES MAY EXPERIENCE SOME NOISES FROM FRONT SUSPENSION, LIKE CREAKING OR CRUNCHING TYPE. MODEL 2012-2013 FOCUS, ESCAPE. *PE
APU-11A01
Service Bulletin/Repair Instructions
LINCOLN/FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A SOFTWARE PROGRAM HAS BEEN PROVIDED TO IMPROVE RESPONSE TO TOUCH, SCREEN REFRESH RATES, OVERALL SYSTEM FUNCTIONALITY, AND VOICE RECOGNITION. *PE UPDATED 4/5/13. *PE UPDATED 10/22/13. *PE
AS1-32241
Service Bulletin/Repair Instructions
FORD: ON VARIOUS VEHICLES WITH MY TOUCH,AFTER ANY APIM PROGRAMMING, REPLACEMENT OR DISCONNECT FROM FRONT DISPLAY INTERFACE MODULE (FDIM), TOUCHSCREEN CALIBRATION MUST BE PERFORMED. MODEL YEARS 2011-2013. NO MODELS LISTED. *PE
ASI-32242
Service Bulletin/Repair Instructions
FORD: ON SOME VEHICLES, TOUCHSCREEN CALIBRATION MUST BE PERFORMED AFTER APIM PROGRAMMING, REPLACEMENT OR DISCONNECT FROM FRONT DISPLAY INTERFACE MODULE (FDIM). MODEL 2012-2013 FOCUS. *PE
APU-12A04
Service Bulletin/Repair Instructions
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A SOFTWARE UPGRADE IS AVAILABLE FOR CERTAIN VEHICLES. MODELS 2012-2013 EDGE, EXPLORER, MKX, FOCUS, ESCAPE, FLEX, FUSION, TAURUS, MKS, MKT, F-150. *PE UPDATED 5/10/13. *PE UPDATED 9/17/13. *PE
CSP-12M02
Service Bulletin/Repair Instructions
FORD/LINCOLN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION REGARDING EXTENDED WARRANTY FOR COVERING ACCESSORY PROTOCOL INTERFACE MODULE REGARDLESS OF MILEAGE. MODELS 2011-2013 EDGE, EXPLORER, MKX, FOCUS, ESCAPE, FLEX, FUSION, TAURUS, MKS, MKT, MKZ, F-150, F-SUPER DUTY. *PE
APU-11A02
Service Bulletin/Repair Instructions
FORD/LINCOLN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING UPGRADE OF TOUCH SOFTWARE TO IMPROVE OVERALL SYSTEM FUNCTIONALITY AND TO SIMPLIFY SCREENS. *PE UPDATED 8/3/12. *PE UPDATED 8/17/12. *PE UPDATED 4/5/13. *PE
APU-11A03-1
Service Bulletin/Repair Instructions
FORD/LINCOLN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION REGARDING IMPROVE OVERALL SOFTWARE SYSTEM FUNCTIONALITY UPGRADE ON VOICE RECOGNITION, RESPONSE TO TOUCH, SIMPLIFY SCREENS FOR EASY USE, AND SCREEN REFRESH RATES. *PE UPDATED 4/5/13. *PE
CSP-12B41
Service Bulletin/Repair Instructions
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DURING TESTING, ACTIVE GRILLE SHUTTER (AGS) WIRE HARNESS ELECTRICAL TERMINALS WAS DAMAGED, AND CAUSES ENGINE TEMPERATURE TO RISE, IF LOUVERS ARE CLOSED AND OPEN CIRCUIT OCCURS, WHEREBY WARNING LIGHT ILLUMINATES, CHIME WILL SOUND AND HIGH ENGINE TEMPERATURE, STOP SAFELY MESSAGE IS DISPLAYED. MODEL 2012 FOCUS. *PE
CSP-12B37
Service Bulletin/Repair Instructions
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLE EXPERIENCE ROLL BACK WHEN TRANSITIONING TO ACCELERATOR PEDAL FROM BRAKE PEDAL WHILE ON INCLINE. TRANSMISSION WOULD BE JERKY OR ROUGH WHEN SHIFTING. PE
CSP-12M01
Service Bulletin/Repair Instructions
FORD/LINCOLN: WARRANTY EXTENSION HAS BEEN PROVIDED FOR CERTAIN MODEL VEHICLES WITH ACCESSORY PROTOCOL INTERFACE MODULE (APIM OR SYNC MODULE) TO 4 (FOUR) YEARS ON FORD AND 5 (FIVE) YEARS ON LINCOLN VEHICLES REGARDLESS OF MILEAGE AND SUBSEQUENT OWNERS ARE AUTOMATICALLY COVERED. *PE
TSB-12-1-7
Service Bulletin/Repair Instructions
FORD: IN THE MESSAGE CENTER, ON SOME MODEL YEAR VEHICLES, THERE ARE DARK HORIZONTAL LINES SHOWING IN INSTRUMENT PANEL AND/OR MAY BE ACCOMPANIED BY ERRATIC GAUGE OR STICKING, INTERMITTENTLY. *PE
CSP-11B31
Service Bulletin/Repair Instructions
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN MODEL YEAR VEHICLES HAVE AN IMPROPERLY BALANCED CLUTCH ASSEMBLY. THIS WILL CAUSE A VIBRATION FELT THROUGH THE SEAT AND/OR STEERING WILL WHILE IN PARK, FIRST GEAR AND NEUTRAL POSITION. *PE
12-2-17
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES MAY EXHIBIT A STEERING WANDER AT HIGHWAY SPEEDS OVER 72 KM/H (45 MPH). CUSTOMERS MAY INDICATE THEY HAVE TO FREQUENTLY ADJUST THE STEERING WHEEL SLIGHTLY TO MAINTAIN THE DIRECTION OF TRAVEL. *JS
TSB-11-5-1
Service Bulletin/Repair Instructions
FORD: THERE MAY BE STEERING ASSIST WARNING LIGHTS AS WELL AS WELL AS A STORED TROUBLE CODE. 2012 FOCUS. *RM
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.